公司新聞
如何處理攤鋪機在施工作業中發生的堵料問題
來源：http://www.stkehao.cn/ 日期：2022-03-29
一旦設備發生堵塞，可以說這是任何公司都不愿意遭遇的棘手問題。在施工作業中選用出租攤鋪機設備之后，如果發生了堵料的現象，這會是嚴重影響設備的生產作業效率，有甚者還會導致嚴重事故的發生。所以說，怎樣預防和妥善解決設備堵塞問題是特別重要的。
Once the equipment is blocked, it can be said that this is a thorny problem that no company is willing to encounter. If the material blockage occurs after the rental paver equipment is selected in the construction operation, it will seriously affect the production and operation efficiency of the equipment, and even lead to serious accidents. Therefore, how to prevent and properly solve the problem of equipment blockage is particularly important.
物料的破碎不能與破碎機分離，如果物料在運輸過程中被堵塞，物料的破碎能力會降低，甚至會影響物料的粒度，如何避免這種現象?聽江蘇匯安工程機械有限公司工程師怎么說：
The crushing of materials cannot be separated from the crusher. If the materials are blocked during transportation, the crushing capacity of materials will be reduced and even affect the particle size of materials. How to avoid this phenomenon? Listen to what the engineer of Jiangsu Huian Construction Machinery Co., Ltd. said:
1、材料預處理
1. Material pretreatment
如果粉碎后的物料水分、粘度等較高，或含有過多未粉碎物料，可對物料進行預篩、預洗，降低粉碎難度。
If the crushed materials have high moisture and viscosity, or contain too many non crushed materials, the materials can be pre screened and pre washed to reduce the difficulty of crushing.
2、三角帶松緊度的調整
2. Tension adjustment triangle
如果三角皮帶過松，這時候就可能會隨槽輪轉動，導致大量物料無法順利破碎，這樣就會留在破碎機的腔中。這很容易造成堵塞問題，所以只需調整三角帶的彈性即可。
If the V-belt is too loose, it may rotate with the sheave at this time, resulting in a large number of materials can not be broken smoothly, which will remain in the chamber of the crusher. This can easily cause blockage, so just adjust the elasticity of the triangular belt.
3、觀察偏心軸是否正常工作
3. Observe whether the eccentric shaft works normally
當偏心軸襯套松動時，偏心軸卡住，不能折斷，因此需要始終注意偏心軸的操作。
When the eccentric shaft bushing is loose, the eccentric shaft is stuck and cannot be broken. Therefore, it is necessary to always pay attention to the operation of the eccentric shaft.
4、報警裝置安裝
4. Installation of alarm device
帶式輸送機的運行電流與卸料量直接相關，如果物料較多，機器很容易引起破碎機跳停，因此，根據這個問題，倒輥式破碎機的入口可以安裝報警裝置，以便與繼電器相連。每當輸送機達到既定的電流峰值，這時就應該及時抽出繼電器，這時候報警裝置自動報警，及時切斷物料供應，延長設備使用壽命。
The running current of the belt conveyor is directly related to the discharge volume. If there are many materials, the machine is easy to cause the crusher to stop. Therefore, according to this problem, the inlet of the inverted roll crusher can be equipped with an alarm device to connect with the relay. Whenever the conveyor reaches the established current peak, the relay should be pulled out in time. At this time, the alarm device will automatically alarm, cut off the material supply in time and prolong the service life of the equipment.
以上就是為大家介紹的有關水泥撒布車出租的詳細介紹,希望對您有所幫助.如果您有什么疑問的話,歡迎聯系我們.我們將以專業的態度,為您提供服務http://www.stkehao.cn
The above is a detailed introduction to the rental of cement spreader. I hope it will be helpful to you If you have any questions, please contact us We will provide you with professional service http://www.stkehao.cn
公司地址：濟南市槐蔭區經一路273號群盛華城2號樓1-404
公司名稱：山東途暢路橋工程有限公司 
備案號：