公司新聞
瀝青攤鋪機租賃的施工分析
來源：http://www.stkehao.cn/ 日期：2021-08-19
了提高潤滑油的潤滑性能，會添加一些添加劑，但使用后很快就會變黑。我們不能認為油已經變質了，可以輕易更換。在判斷潤滑油是否變質時，應進行綜合分析。
In order to improve the lubricating performance of lubricating oil, some additives will be added, but it will turn black soon after use. We can't think that the oil has gone bad and can be replaced easily. Comprehensive analysis shall be conducted when judging whether the lubricating oil has deteriorated.
攤鋪機操作說明書規定的油品等級適用于一般工況。在換油和維護過程中，還應考慮實際操作條件。如果實際操作條件比規定條件苛刻，應選擇好油品。
The oil grade specified in the paver operation manual is applicable to general working conditions. Actual operating conditions shall also be considered during oil change and maintenance. If the actual operating conditions are more severe than the specified conditions, the oil shall be selected.
攤鋪機中少量的油會導致供油不足和潤滑不良。因此，由于擔心石油不足，沒有必要增加更多的石油。過量的潤滑油不僅會由于旋轉阻力的增加而增加曲軸的功耗，而且容易導致潤滑不良。
A small amount of oil in the paver will lead to insufficient oil supply and poor lubrication. Therefore, there is no need to add more oil due to the fear of oil shortage. Excessive lubricating oil will not only increase the power consumption of the crankshaft due to the increase of rotating resistance, but also easily lead to poor lubrication.
1、如果使用新的攤鋪機，我們建議我們應該注意設備的磨合情況，它有磨合期。如果不注意設備的磨合，就會加速設備部件的磨損。
1. If a new paver is used, we suggest that we should pay attention to the running in of the equipment, which has a running in period. If you do not pay attention to the running in of the equipment, it will accelerate the wear of equipment components.
2、攤鋪機上的空氣過濾元件和攤鋪機的租約都建議我們及時清理或更新。所用的油也應該及時更換。使用不合格的機油也會影響設備的發動機。
2. The air filter elements on the paver and the lease of the paver suggest that we clean or update them in time. The oil used should also be replaced in time. The use of unqualified engine oil will also affect the engine of the equipment.
3、平時使用瀝青攤鋪機租賃時，應注意檢查設備，有無異常噪音，操作中有無打滑現象，并及時觀察設備系統是否過熱。
3. When using the asphalt paver for lease at ordinary times, pay attention to check the equipment for abnormal noise and slip during operation, and timely observe whether the equipment system is overheated.
瀝青攤鋪機租賃
Asphalt paver leasing
在進行地面施工時，瀝青攤鋪機的使用率很高。它不僅效果好，而且平面度誤差小。如果混凝土瀝青攤鋪機在磨損機上，維護保養的重點是什么？
During ground construction, the utilization rate of asphalt paver is very high. It not only has good effect, but also has small flatness error. If the concrete asphalt paver is on the wear machine, what is the focus of maintenance?
1、瀝青攤鋪機的操作人員應接受制造商的培訓和領導，對機器的結構和性能有足夠的了解，并具備操作機器所必需的操作和維護經驗。
1. The operators of the asphalt paver shall receive the training and leadership of the manufacturer, have a sufficient understanding of the structure and performance of the machine, and have the necessary operation and maintenance experience to operate the machine.
2、試運轉期間應注意工作量。磨合期的工作量不應超過額定工作量的80%。應配置適當的工作負荷，以防止機器長期連續運行導致過熱。
2. Pay attention to the workload during commissioning. The workload during the running in period shall not exceed 80% of the rated workload. Appropriate working load shall be configured to prevent overheating caused by long-term continuous operation of the machine.
3、應注意經常檢查各儀表的情況，發現異常情況，及時停車排除，排除故障前應停止操作。
3. Pay attention to check the condition of each instrument frequently. If abnormal conditions are found, stop the machine in time for troubleshooting. Stop the operation before troubleshooting.
4、注意檢查混凝土激光攤鋪機的潤滑油、液壓油、制動液和燃油油位，檢查攤鋪機的密封情況。檢查中發現油、水過多，應分析原因。
4. Pay attention to check the lubricating oil, hydraulic oil, brake fluid and fuel level of the concrete laser paver, and check the sealing of the paver. If too much oil and water are found during the inspection, the cause shall be analyzed.
5、保持攤鋪機清潔，及時調整和擰緊松動件，防止松動件磨損或丟失。
5. Keep the paver clean, adjust and tighten the loose parts in time to prevent the loose parts from being worn or lost.
公司地址：濟南市槐蔭區經一路273號群盛華城2號樓1-404
公司名稱：山東途暢路橋工程有限公司 
備案號：